Product ID:1205 PRIME COAT
MSDS Date:11/21/1996
FSC:8040
NIIN:01-381-1968
Status Code:A
MSDS Number: CJDML

DOW CORNING CORPORATION

SOUTH SAGINAW ROAD
MIDLAND, MI 48686
US

Emergency Phone: 517-496-5900

Cage: 71984

NAVY ENVIRONMENTAL HEALTH CENTER

NORFOLK, VA 23513-2617 US

Telephone: 804-444-4657, DSN 564-4657 X 272

Cage: SO010

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

2-PROPANOL, 1-METHOXY- (PROPYLENE GLYCOL METHYL ETHER)

CAS: 107-98-2

RTECS: UB7700000

ACGIH TLV: 369 MG/M3;100 PPM

GLYCOL MONOBUTYL ETHER ACETATE (BUTYL GLYCOL ACETATE)

CAS: 112-07-2

RTECS: KJ8925000

BISPHENOL A-BISPHENOL A DIGLYCIDYL ETHER POLYMER (EPOXY

CAS: 25036-25-3

2-METHOXYPROPANOL

CAS: 1589-47-5

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: DIRECT CONT IRRITATES. MAY BE
SERIOUS W/REDNESS, SWELLING & SOME CORNEAL INJURY LASTING SEVERAL
DAYS TO A WEEK. SKIN: SINGLE RELATIVELY SHORT EXPOS (LESS THAN 24
HRS) IRRITATES. RPTD PRLNGD CONT (24 TO 48 HRS) IRRITATES
SERIOUSLY, MAYBURN MILDLY. OVEREXP MAY INJURE INTERNALLY IF
ABSORBED. ALSO SEE COMMENT. INHAL: SHORT VAP EXPOS MAY CAUSE DROW &
IRRIT NOSE & THROAT. DEGREE OF EFTS DEPENDS ON CONC & LENGTH OF
EXPOS. VAPS MAY INJURE BLOOD, LUNGS, KIDNEYS, EYES & NERVOUS SYS.
DEGREE OF INJURY WILL DEPEND ON CONC & DURATION OF EXPOS. INGEST:
SMALL AMTS TRANS TO MOUTH BY FINGERS DURING USE, ET C, (EFTS OF
OVEREXP)
Effects of Overexposure:HLTH HAZ: SHOULD NOT INJURE. SWALLOWING LARGE
AMTS MAY INJURE SERIOUSLY. INHAL LIQ WHILE VOMIT CAN INJURE LUNGS
SERIOUSLY. COMMENT: PRLNGD SKIN CONT WITH VERY LARGE AMTS OF
PROPYLENE GLYCOL METHYL ETH ER MAY CAUSE DROW. CHRONIC: TOLUENE
APPEARS ON THE NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ
LIST INFO & SAFE HNDLG & EXPOS INFO . ANIMAL STUDIES HAVE CLEARLY
SHOWN DOSE-RELATED EFTS ON THE CNS, HEMOTOPOIETICTISS, BLOOD,
KIDNEYS & LIVER ASSOC W/ADMIN OF ETHYLENE GLYCOL MONOBUTYL ETHER
ACETATE (EGBEA). EXTRACTED FROM (SUPDAT)
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO ANY CHEMICAL MAY
RESULT IN ENHANCEMENT OF PRE-EXISTING ADVERSE MEDICAL CONDITIONS
AND ALLERGIC REACTIONS.

First Aid:EYES: IMMEDIATELY FLUSH WITH WATER FOR AT LEAST 15 MINUTES.
GET MEDICAL ATTENTION. SKIN: WIPE OFF AND FLUSH WITH WATER FOR 15
MINUTES. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS. INHALATION:
REMOVE TO FRESH AIR. GET MEDICAL ATTENTION IF ILL EFFECTS PERSIST.
INGESTION: GET MEDICAL ATTENTION. DO NOT INDUCE VOMITING. COMMENT:
IF VOMITING OCCURS, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
LIQUID INTO LUNGS.

Flash Point Method:CC
Flash Point:=5.C, 41.F
Lower Limits:N/D
Upper Limits:N/D
Extinguishing Media:WATER FOG, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:VAPORS ARE HEAVIER THAN AIR AND CAN
TRAVEL ALONG THE GROUND TO REMOTE IGNITION SOURCES. STATIC
ELECTRICITY MAY ACCUMULATE AND IGNITE VAPORS. PREVENT A POSSIBLE
FIRE HAZARD BY SUITABLE MEANS, SUCH AS, BONDING AND GROUNDING,
INERT GAS PURGE,VAPOR DILUTION AND THE LIKE.

Spill Release Procedures:USE ABSORBENT MATERIAL TO COLLECT AND CONTAIN
FOR SALVAGE OR DISPOSAL. REMOVE ALL SOURCES OF IGNITION AND WEAR
PROPER PROTECTION EQUIPMENT.

Handling and Storage Precautions:NONE SPECIFIED BY MANUFACTURER.
Other Precautions:NONE SPECIFIED BY MANUFACTURER.

Respiratory Protection:USE NIOSH APPROVED RESPIRATORY PROTECTION UNLESS
LOCAL EXHAUST VENTILATION IS ADEQUATE OR AIR SAMPLING DATA SHOWS
EXPOSURES ARE WITHIN TLV AND PEL GUIDELINES.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:RUBBER OR PLASTIC GLOVES.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYEWASH AND DELUGE SHOWER MEETING
ANSI DESIGN CRITERIA .
Work Hygienic Practices:WASHING AT MEALTIME AND END OF SHIFT IS
ADEQUATE. IF A SPLASH OCCURS, CHANGE CONTAMINATED CLOTHING AS SOON
AS POSSIBLE AND THOROUGHLY FLUSH AFFECTED AREAS WITH COOL WATER.
Supplemental Safety and Health
EFTS OF OVEREXP: DHHS (NIOSH) PUB NO 90-118 . TOXICOLOGICAL STUDIES
WITH LAB ANIMALS & OCCUP EXPOS EVALS W/HUMANS HAVE FOUND LIMITED
EVID OF BIRTH DEFECTS, LOW BIRTH WEIGHTS & DELAYED GROWTH OF
OFFSPRING RSLTG FROM RPTD EXPOS TO TOLUENE DURING PREGNACY. ABOVE
LISTED POTNTL EFTS OF OVEREXP ARE BASED (OTHER INFO).

HCC:F3
Boiling Pt:B.P. Text:NOT DETERMINED
Vapor Pres:NOT DETERMINED
Vapor Density:>1 (AIR=1)
Spec Gravity:0.9 @ 77F/25C
Evaporation Rate & Reference:NOT DETERMINED
Solubility in Water:NOT DETERMINED
Appearance and Odor:SOLVENT ODOR, LIQUID, WATER WHITE TO LIGHT STRAW.
Percent Volatiles by Volume:95 BY WEIGHT

Stability Indicator/Materials to Avoid:YES
OXIDIZING MATERIAL CAN CAUSE A REACTION.
Stability Condition to Avoid:EXPOSURE TO AIR UNTIL READY TO USE.
Hazardous Decomposition Products:SILICON DIOXIDE, CARBON DIOXIDE AND
TRACES OF INCOMPLETELY BURNED CARBON PRODUCTS, INCLUDES
FORMALDEHYDE.

Waste Disposal Methods:DOW CORNING SUGGESTS THAT ALL LOCAL, STATE AND
FEDERAL REGULATIONS CONCERNING HEALTH AND POLLUTION BE REVIEWED TO
DETERMINE APPROVED DISPOSAL PROCEDURES. CONTACT DOW CORNING IF
THERE ARE ANY DISPOSAL QUESTIONS.

Toxicological Information:TOXICOLOGY STUDIES WITH LABORATORY ANIMALS
AND OCCUPATIONAL EXPOSURE EVALUATIONS WITH HUMANS HAVE FOUND
LIMITED EVIDENCE OF BIRTH DEFECTS, LOW BIRTH WEIGHT AND DELAYED
GROWTH OF OFFSPRING RESULTING FR OM REPEATED EXPOSURE TO TOLUENE
DURINGPREGNANCY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:SEE FEDERAL REGULATIONS.

Federal Regulatory Information:DOT (49 CFR 171.8)/EPA (40 CFR 117)
SPILL REPORTING INFO HAZ SUBSTANCE: SEE BELOW. RQ: SEE BELOW. CONC
OF HAZ SUSTANCE: SEE WT % BELOW. RQ OF PROD: SEE BELOW. COMMENTS:
DOT & EPA - CERCLA/SARA ENVIRON MENTAL RELS REPORTING REGS
CURRENTLY APPLICABLE TO PROD INGRED SHOWN BELOW. INGRED: TOLUENE.
CAS NO: 108-88-3. RQ: 1,000 LBS. WT %: 40. RQ OF PROD:2,500 LBS.
PROD IS OIL IN CONTEXT OF U.S. CLEAN WATER ACT. SPILLS TO U.S.
SURFACE WATERS OR TO A WATER COURSE OR SEWER LEADING TO U.S.
SURFACE WATERS THA T CAUSE VISIBLE SHEEN MUST BE REPORTED TO THE
NATIONAL RESPONSE CENTER.